1958 Austin-Healey 100/6
£85,000 | Location: United Kingdom
The BN6 was the final development of the Healey 100/6 two-seater roadster before being replaced by the Healey 3000 (BT7) in 1959. Chassis no BN6-L/3516 was built at MG's Abingdon works between the 30th September and 2nd October 1958 and shipped to a dealer in San Francisco on the 13th of October.
After 32 years of enjoying life in the States and with 54,000 miles on the odometer, this 'Big Healey' crossed the Atlantic once again and joined the collection of a Channel Islands resident who is a long-term Healey enthusiast. He decided to carry out a 'nut and bolt' restoration with great attention to detail hoping to achieve a Concours winning standard.
The six-port, cylinder head has been reconditioned and converted to unleaded compatibility with new valves, valve seats, seals etc. The block was cleaned inside and out, re-bored to +0.020 and fitted with new pistons and rings and top end bearings. The crank shaft was within 0.0005 of original so polished only and refitted with new bearings, thrust washers, big end bolts and main bearing nuts. The timing chain and tensioner have been replaced and the water pump reconditioned. All oil and waterways in the block and cylinder head were cleaned and the core plugs renewed.
The rear axle and differential were dismantled, cleaned and assembled using new parts where required, and the clutch and gearbox were fully reconditioned using new parts. The steering and braking systems have been completely overhauled and new tyres fitted.
All electrical components have either been overhauled or replaced with new items including a complete new braided wiring harness. A new aluminium fuel tank has been fitted along with new fuel lines and fuel pump and the carburettors have been fully reconditioned and set up appropriately. A complete, stainless steel, exhaust system and brackets were fitted.
Whenever possible, the original exterior trim has been re-chromed to a very high standard with new brightwork added only when necessary. The hood and tonneau cover are new, the side screens have been reconditioned, and the windscreen glass is new. The interior was completely re-trimmed to an extremely high standard, and features navy blue leather upholstery with white piping and well-fitted carpets in navy blue
Finally, after weeks of preparation, the Healey was carefully repainted in period Ice Blue over Old English White and the tight shut-lines and depth of finish will reward any inspection. This Austin Healey is as immaculate underneath as it is on top.
Since this extensive restoration to Concours standard, the car has been driven approximately 200 miles in the Jersey sunshine and any little rattles or niggles eradicated.